PASSIVITY-BASED SLIDING MODE CONTROLLER/OBSERVER FOR A LIGHTWEIGHT ROBOTIC ARM
DOI:
https://doi.org/10.59277/RRST-EE.2026.3.19Keywords:
Lightweight robotic arm, Passivity-based control, Sliding mode observer, Euler-Lagrange formalism, Assumed modes approachAbstract
This paper presents a passivity-based sliding-mode controller-observer for a two-link lightweight robotic arm that accounts for structural flexibility and payload mass. The system’s dynamical model is obtained using the Euler-Lagrange formalism and the assumed modes method. The resulting mathematical model is highly nonlinear, with strong coupling between the rigid dynamics and the system's elastic behavior. To achieve accurate trajectory tracking with effective strain elimination, a full-order sliding-mode state observer is designed to estimate the state variables in the presence of parameter uncertainties and external perturbations. Then, the robust observer is combined with a passivity-based controller that uses the estimated states to achieve the desired trajectory, thereby improving system performance and robustness. The stability of the global system is demonstrated using Lyapunov theory and accounting for the passivity property, whereby the total energy is dissipated or stored within the system. The proposed controller/observer is evaluated using MATLAB/Simulink. Simulation results show good trajectory tracking with effective rejection of the external perturbations.
References
(1) A. Belherazem, R. Salim, A. Laidani, M. Chenafa, “Vibration control of a two-link flexible manipulator.” Automatic Control and Computer Sciences, 58, pp. 346–358 (2024).
(2) Q. Meng, X. Lai, Z. Yan, C.Y. Su, M. Wu, “Motion planning and adaptive neural tracking control of an uncertain two-link rigid–flexible manipulator with vibration amplitude constraint.” IEEE Trans. Neural Netw. Learn. Syst. (2022).
(3) B. Xu, P. Zhang, “Composite learning sliding mode control of flexible-link manipulator.” Complexity, article ID 9430259 (2017).
(4) M. Boussoffara, I. Bencheikh Ahmed, Z. Hajaiej, “Sliding mode controller design: Stability analysis and tracking control for flexible joint manipulator.” Rev. Roum. Sci. Techn. – Électrotechn. Et Énerg., 66, 3, pp. 161–167 (2021).
(5) A. Belherazem, M. Chenafa, “Passivity-based adaptive control of a single-link flexible manipulator.” Automatic Control and Computer Sciences, 55, pp. 1–14 (2021).
(6) H.M. Yatim, I.Z. Darus, M.H. Ab. Talib, M.H. Abu Bakar, “Active vibration control of flexible manipulator using genetic algorithm with parameter exchanger.” IEEE 8th International Conference on Smart Instrumentation, Measurement and Applications (ICSIMA) (2022).
(7) H. Djerbi, I. Al-Darraji, G. Tsaramirsis, M. Khchaou, R. Abbassi, O. Alshammari, “Fuzzy Luenberger observer design for nonlinear flexible joint robot manipulator.” Electronics, 11, 10 (2022).
(8) D.H. Bui.Phuc, J.A. Scultz, “A semilinear parameter-varying observer method for fabric-reinforced soft robots.” Frontiers in Robotics and AI, 8 (2021).
(9) M. Khairudin, Z. Mohamed, A.R. Husain, M.A. Ahmad, “Dynamic modeling and characterization of a two-link flexible robot manipulator.” Journal of low frequency noise, vibration and active control, pp. 207–219 (2010).
(10) M.W. Spong, M. Vidyasagar, S. Hutchinson, “Robot modeling and control.” John Wiley & Sons (2006).
(11) T. Hatanaka, N. Chopra, M. Fujita, M. Spong, “Passivity-based control and estimation in networked robotics.” Communication and Control Engineering, Springer (2015).
(12) J.P. Barbot, T. Boukhobza, M. Djemai, “Sliding mode observer for triangular input form.” Proceedings of the 35th IEEE Conference on Decision and Control (1996).
(13) A. Belherazem, Commande non-linéaire robuste d'un bras manipulateur flexible, Thèse de doctorat, ENP Oran (2022).
(14) L. Li, F. Cao, J. Liu, “Vibration control of flexible manipulator with unknown control direction.” International Journal of Control, 94, 10 (2021).
(15) A. Belherazem, Z. Bellahcene, A. Laidani, “Passivity-based control of a two-link flexible manipulator.” The 1st International Conference on Advances in Electronics, Control and Computer Technologies ICAECT’23, Mascara, Algeria (2023).
(16) W. Nan, H. Qin, “A velocity self-learning algorithm for time-optimal trajectory planning along the fully specified path - Part I.” Rev. Roum. Sci. Techn. – Électrotechn. Et Énerg., 70, 1, pp. 109–114 (2025).
(17) W. Nan, H. Qin, “A velocity self-learning algorithm for time-optimal trajectory planning along the fully specified path - Part II.” Rev. Roum. Sci. Techn. – Électrotechn. Et Énerg., 70, 1, pp. 241–246 (2025).
Downloads
Published
Issue
Section
License
Copyright (c) 2026 REVUE ROUMAINE DES SCIENCES TECHNIQUES — SÉRIE ÉLECTROTECHNIQUE ET ÉNERGÉTIQUE
This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.
